VW Touran Klub Polska

Proszę o interpretację błędów po pierwszym skanie VCDS.

Address 01: Engine Labels: 03G-906-021-BMM.clb
Part No SW: 03G 906 021 MJ HW: 03G 906 021 AB
Component: R4 2,0L EDC G000SG 2115
Revision: --H08--- Serial number: VWX7Z0H63N30YI
Coding: 0000072
Shop #: WSC 01324 785 00200
VCID: 73EFC11512AE091

1 Fault Found:
005658 - Glowplug for Cylinder 1 (Q10)
P161A - 000 - Open Circuit
Freeze Frame:
Fault Status: 01110000
Fault Priority: 3
Fault Frequency: 1
Mileage: 164358 km
Time Indication: 0
Date: 2000.00.00
Time: 08:35:41

Freeze Frame:
RPM: 189 /min
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 9.88 V
Bin. Bits: 00101100
Temperature: 1.8°C
Bin. Bits: 01110000

Readiness: 0 0 0 0 0
----------------------
Address 18: Aux. Heat Labels: None
Part No: 1K0 815 071 T
Component: Zuheizer 050 2504
Revision: 00050000 Serial number: 09009839000000
Coding: 0000011
Shop #: WSC 01324 785 00200
VCID: 36693801415C5C9

2 Faults Found:
01415 - Recirculating Pump (V55)
007 - Short to Ground
Freeze Frame:
Fault Status: 01100111
Fault Priority: 3
Fault Frequency: 254
Reset counter: 247
Mileage: 78500 km
Time Indication: 0

Freeze Frame:
Locked
Temperature: 91.0°C
Temperature: 90.0°C
Voltage: 14.24 V

02251 - Heater Unit Locked
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 247
Mileage: 86970 km
Time Indication: 0

Pozdrawiam

Zablokowane webasto oraz prawdopodobnie uszkodzona pompka jak usunąć?

i w ogóle coś ci świece szfankują

005658 - Glowplug for Cylinder 1 (Q10) - Najprawdopodobniej spalona świeca do wymiany
01415 - Recirculating Pump (V55) - pompy wymuszenia obiegu wody V-55 najprawdopodobniej padnięta pompa tutaj było o tym na forum Pompka obiegowa V55

to ja się podepnę pod temat zeby nie zakladac nowego skan z tourana (doprowadzamy do porządku autko znajomego)


Wednesday,29,May,2013,12:53:32:32264
VCDS Version: Release 11.11.3
Data version: 20120401



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 1K0
Scan: 01 03 08 09 15 16 17 18 19 25 42 44 46 52 62 69 72 77

VIN: ************** Mileage: *****************

00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
18-Aux. Heat -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
69-Trailer -- Status: Cannot be reached 1100
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000

-------------------------------------------------------------------------------
Address 01: Engine Labels: 03G-906-016-BKC.lbl
Part No SW: 03G 906 016 CD HW: 028 101 194 5
Component: R4 1,9L EDC G010SG 6246
Revision: 12345678 Serial number: VWZ7Z0D0834140
Coding: 0000072
Shop #: WSC 01324 785 00200
VCID: 67D7A5455676F51

No fault code found.
Readiness: 0 0 1 1 1

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No: 1K0 907 379 K
Component: ESP FRONT MK60 0104
Coding: 0021190
Shop #: WSC 01324 785 00200
VCID: 3A712C317544B89

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-907-044.lbl
Part No: 1K0 907 044 AC
Component: ClimatronicPQ35 066 0404
Shop #: WSC 00000 000 00000
VCID: 68D5A6795B68FA9

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 3C0-937-049-23-H.lbl
Part No SW: 1K0 937 049 N HW: 1K0 937 049 N*
Component: Bordnetz-SG H34 0803
Revision: 00H34000 Serial number: 00000001134965
Coding: 018B8F020004100000120C000000000000087F075C
Shop #: WSC 00000 000 00000
VCID: 3A712C317544B89

Subsystem 1 - Part No: 1T0 955 119 C Labels: 1KX-955-119.CLB
Component: Wischer VW358 012 0401
Coding: 00065493
Shop #: WSC 00000

2 Faults Found:
01517 - Control Module for Trailer/Towing Sensor (J345)
004 - No Signal/Communication
02092 - Enabling Heated Seat
009 - Open or Short to Ground

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1T0-909-605.lbl
Part No SW: 1T0 909 605 C HW: 1T0 909 605 C
Component: 02 AIRBAG VW62 0506 1500
Revision: 09025000 Serial number: 0038BD09V5GA
Coding: 0012338
Shop #: WSC 01324 785 00200
VCID: 356B3F0D5C5A571

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 A HW: 1K0 953 549 A
Component: Lenksäulenmodul 012 0030
Coding: 0000042
Shop #: WSC 01324 785 00200
VCID: 30650E19A338729

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No: 1T0 920 861 A
Component: KOMBIINSTRUMENT VDD 0814
Coding: 0007103
Shop #: WSC 00012 000 00000
VCID: 30650E19A338729

No fault code found.

-------------------------------------------------------------------------------
Address 18: Aux. Heat Labels: None
Part No: 1K0 815 071 H
Component: Zuheizer 031 1312
Revision: A Serial number: 09010046
Coding: 0000011
Shop #: WSC 49484 126 85304
VCID: 2A511C7185E4089

5 Faults Found:
01411 - Temperature Sensor (G18)
007 - Short to Ground - Intermittent
Freeze Frame:
Fault Status: 00100111
Fault Priority: 0
Fault Frequency: 9
Reset counter: 147
Mileage: 212247 km
Time Indication: 0
Date: 2000.00.00
Time: 27:54:15

Freeze Frame:
Malfunction
Temperature: 205.0°C
Temperature: 45.0°C

01415 - Recirculating Pump (V55)
010 - Open or Short to Plus - Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 0
Fault Frequency: 79
Reset counter: 175
Mileage: 215175 km
Time Indication: 0
Date: 2000.00.00
Time: 28:35:10

Freeze Frame:
OFF
Temperature: 158.0°C
Temperature: 18.0°C

01410 - Heater Over-Temp
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 0
Fault Frequency: 1
Reset counter: 147
Mileage: 212236 km
Time Indication: 0
Date: 2000.00.00
Time: 19:52:19

Freeze Frame:
Ctrl. Pause
Temperature: 148.0°C
Temperature: 45.0°C

02251 - Heater Unit Locked
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 0
Fault Frequency: 1
Reset counter: 147
Mileage: 212236 km
Time Indication: 0
Date: 2000.00.00
Time: 19:52:19

00664 - Fuel gauge
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 0
Fault Frequency: 13
Reset counter: 125
Mileage: 213225 km
Time Indication: 0
Date: 2000.00.00
Time: 29:41:57


-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 E HW: 1K0 907 951
Component: Gateway H09 0110
Revision: 09 Serial number: 2700104A110185
Coding: 3D3F5380078002
Shop #: WSC 01324 785 00200
VCID: 2953E37D80E2031

1 Fault Found:
01517 - Control Module for Trailer/Towing Sensor (J345)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 175
Mileage: 215175 km
Time Indication: 0
Date: 2000.00.00
Time: 12:51:51


-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No: 1T0 920 861 A
Component: IMMO VDD 0814
Shop #: WSC 00000 000 00000
VCID: 30650E19A338729

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MIN1.lbl
Part No: 1T0 959 701
Component: Tuersteuergeraet 09 0157
Coding: 0000116
Shop #: WSC 01324 785 00200
VCID: F4ED420997A08E9

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K1 909 144 G
Component: EPS_ZFLS Kl.0 1401
Shop #: WSC 00000 000 00000
VCID: 2F670D65BE066D1

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 1K0-959-433-MIN.clb
Part No: 1K0 959 433 BL
Component: 01 KSG 0301
Coding: 80E802087F2D8404084F016011
Shop #: WSC 72842 123 80520
VCID: 7BFFE9353AFE411

Component: Sounder n.mounted

Component: NGS n.mounted

Component: IRUE n.mounted

1 Fault Found:
01517 - Control Module for Trailer/Towing Sensor (J345)
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MIN1.lbl
Part No: 1T0 959 702
Component: Tuersteuergeraet 09 0157
Coding: 0000116
Shop #: WSC 01324 785 00200
VCID: F5EB7F0D9CDA971

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN1.lbl
Part No: 1K0 959 703 B
Component: Tuersteuergeraet 06 0214
Coding: 0000048
Shop #: WSC 01324 785 00200
VCID: 2F670D65BE066D1

No fault code found.

-------------------------------------------------------------------------------
Address 69: Trailer
Cannot be reached

-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN1.lbl
Part No: 1K0 959 704 B
Component: Tuersteuergeraet 06 0214
Coding: 0000048
Shop #: WSC 01324 785 00200
VCID: 30650E19A338729

No fault code found.

-------------------------------------------------------------------------------
Address 77: Telephone Labels: 1K0-035-729-UNI.lbl
Part No: 1K0 035 729 E
Component: CIB PAH HW 202 SW 0308
Coding: 0000364
Shop #: WSC 00000 000 00000
VCID: 2B5F19758A1E111

No fault code found.

End ---------------------------------------------------------------------

[ Dodano: Wto Cze 04, 2013 22:05 ]
halooo

Mam takie błędy i szukam przyczyny

00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
18-Aux. Heat -- Status: Malfunction 0010
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
76-Park Assist -- Status: OK 0000
77-Telephone -- Status: OK 0000

-------------------------------------------------------------------------------
Address 01: Engine Labels: Redir Fail!
Part No SW: 03G 906 021 MJ HW: 03G 906 021 AB
Component: R4 2,0L EDC G000SG 0484
Revision: --H06--- Serial number: VWX7Z0G23NJ0TX
Coding: 0000072
Shop #: WSC 00001 000 00000
VCID: 73E1DBFF6975

3 Faults Found:
005658 - Glowplug for Cylinder 1 (Q10): Open Circuit
P161A - 000 - -
Freeze Frame:
Fault Status: 01110000
Fault Priority: 3
Fault Frequency: 1
Mileage: 247697 km
Time Indication: 0
Date: 2000.00.00
Time: 07:19:37

Freeze Frame:
RPM: 147 /min
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 10.26 V
Bin. Bits: 00001100
Temperature: 8.1°C
Bin. Bits: 01110000

005660 - Glowplug for Cylinder 3 (Q12): Open Circuit
P161C - 000 - -
Freeze Frame:
Fault Status: 01110000
Fault Priority: 3
Fault Frequency: 5
Mileage: 247697 km
Time Indication: 0
Date: 2000.00.00
Time: 07:19:37

Freeze Frame:
RPM: 147 /min
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 10.26 V
Bin. Bits: 00001100
Temperature: 8.1°C
Bin. Bits: 01110000

001139 - Exhaust Pressure Sensor 1 (G450): Signal too High
P0473 - 000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 2
Fault Frequency: 29
Mileage: 249437 km
Time Indication: 0
Date: 2000.00.00
Time: 08:42:33

Freeze Frame:
RPM: 2709 /min
Speed: 19.0 km/h
Load: 54.1 %
Voltage: 14.44 V
Mileage: 100 km
Temperature: 300.0°C
Absolute Pres.: 1815.6 mbar

Readiness: 1 1 0 0 0

Może ktoś doradzi co może być przyczyna zapala mi się kontrolka silnika a błędy wyskakują jak powyżej

Check masz od czujnika różnicy ciśnień na DPFie.
Przy tym przebiegu całkiem możliwe, że DPF do kastracji, ale sugeruję na początek podmienić ten czujnik bo na 90% jest uszkodzony.

Nie zaszkodzi przy okazji zerknąć vcds na stan dpf w blokach pomiarowych. Dpf sprawdzamy na dogrzane silniku. .. to tak BTW.
Jak nie wiesz co i jak to służę pomocą na telefonie w godz 8.00-20.00

Wymieniłem czujnik i problem zniknął wymieniłem też świece i z dwóch błędów świec został mi jeden na 3 cylindrze więc chyba bedzie uszkodzona wiązka zasilająca świece tak mi się wydaje z tego co wyczytałem na fotum dzięki za wszystkie pomocne podpowiedzi

Pytasz, dajesz odczyt to i pomoc jest. Cieszę się, że pomogłem.

A to moje dane z DPF:
blok 068
1 =2,8%
2 =27,0
3 =0,0%
blok 70
1 =00000100
2 =0,0s
3 =0,0
4 =0,0
blok 75
1 =150,0 C
2 =144,0 C
3 =2,8%
4 =234,0 C
I jak to wygląda czy na razie jest ok

Zapełnienie w chwili sprawdzenia jak najbardziej ok.
Sprawdź jeszcze raz i za tydzień, jak parametr będzie zbliżony to masz luz. Jak będzie skakał to do obserwacji.